Product ID:ROYCO (R) 27
MSDS Date:05/01/1998
FSC:9150
NIIN:00-935-4017
Status Code:A
MSDS Number: CJVLP

ROYAL LUBRICANTS COMPANY INC.

EAST HANOVER, NJ 07936-0518
US

Emergency Phone: 973-837-7410

Info Phone: 973-837-7410

Preparer: PRODUCT SAFETY RLC INC

Cage: 07950

ROYAL LUBRICANTS COMPANY INC.

518 EAST HANOVER, NJ 07936 US

Telephone: 973-887-7411/7410

Cage: 07950

ROYCO 27, LUBRICATING GREASE

SYNTHETIC ESTER

CAS: 1330-86-5

LITHIUM HYDROXYSTEARATE

CAS: 7620-77-1

ANTIMONY DIALKYDITHIOCARBAMATE

CAS: 15991-76-1

P,P'-DIOCTYLDIPHENYLAMINE

CAS: 68411-46-1

MINOR ADDITIVES

LD50 LC50 Mixture:ACUTE ORAL LD50: N/P.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CONTACT MAY BE SLIGHTLY
IRRITATING. SKIN; PROLONGED OR REPEATED CONTACT MAY CAUSE VARIOUS
SKIN DISORDERS SUCH AS DERMATITIS, FOLLICULITIS, OR OIL ACNE.
RELEASE DURING HIGH PRESSURE USAGE MAY RESULT IN INJECTION OF OIL
INTO THESKIN CAUSING NECROSIS. INHALATION: NOT A RELEVANT ROUTE OF
EXPOSURE, HOWEVER, UNDER HIGH TEMPERATURE CONDITIONS VAPORS
IRRITATING TO THE NOSE, THROAT, AND UPPER RESPIRATORY TRACT MAY BE
PRODUCED. INGESTION: NO SPECIFIC INFORMATION IDENTIFIED.
CHRONIC:THIS SPECIFIC PRODUCT HAS NOT BEEN TESTED IN LONG-TERM,
CHRONIC EXPOSURE TESTS.
Effects of Overexposure:EYE CONTACT: IRRITATION. SKIN CONTACT:
DERMATITIS, FOLLICULITIS, OIL ACNE. LOCAL NECROSIS, EVIDENCED BY
DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS FOLLOWING
INJECTION. INHALATION: IRRITATIO N OF NOSE, THROAT AND UPPER
RESPIRATORYTRACT. INGESTION: NO SPECIFIC INFORMATION IDENTIFIED.
Medical Cond Aggravated by Exposure:PREEXISTING EYE AND SKIN DISORDERS
MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WIPE EXCESS OFF. WASH W ITH SOAP AND WATER OR WATERLESS HAND
CLEANER FOLLO WED BY SOAP AND WATER. IF IRRITATION PERSISTS, GET
MEDICAL ATTENTION. IF MATERIAL IS INJECTED UNDER SKIN, GET MEDICAL
ATTENTION PROMPTLY. INHALATION: MOVE TO FRESH AIR. GIVE OXYGEN IF
BREATHING IS DI FFICULT. GET MEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. IN GENERAL, NO TREATMENT NECESSARY UNLESS LARGE
QUANTITIES OF PRODUCT INGESTED. GET MEDICAL ADVICE.

Flash Point:NOT AVAILABLE
Autoignition Temp:Autoignition Temp Text:NOT AV
Lower Limits:NOT AVAILABL
Upper Limits:NOT AVAILABL
Extinguishing Media:USE WATER FOG, DRY CHEMICAL OR CARBON DIOXIDE. DO
NOT USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED ON SURFACE OF WATER.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT
PROPER PROTECTIVE EQUIPMENT INCLUDING A NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS
SURROUNDING EQUIPMENT AND STRUCTURES WI TH WATER.

Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER. PREVENT SPILL FROM ENTERING SEWERS, SURFACE
WATERS OR ANY WATER COURSES. ANY SPILLS ENTERING SURFACE WATERS OR
ANY WATERCOURSES OR SEWERS ENTERING/LEAVING TO SURFACE WATERS
THATCAUSE A SHEEN MUST BE REPORTED TO NATIONAL RESPONSE CENTER
800-424-8802.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES. MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOLIET FACILITIES.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Other Precautions:PROPERLY DISPOSE OF CONTAMINATED LEATHER ARTICLES,
INCLUDING SHOES THAT CANNOT BE DECONTAMINATED.

Respiratory Protection:NOT ORDINARILY REQUIRED.
Protective Gloves:USE OIL RESISTANT GLOVES.
Eye Protection:EYE PROTECTION SHOULD BE WORN DURING HIGH PRESSURE
APPLICATIONS.
Other Protective Equipment:USE OIL RESISTANT CLOTHING AS NEEDED TO
MINIMIZE SKIN CONTACT.
Supplemental Safety and Health

HCC:V6
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE
Vapor Pres:NOT AVAILABLE
Vapor Density:NOT AVAILA
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:INSOLUBLE
Appearance and Odor:TAN, SMOOTH, SLIGHT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, OPEN FLAME.
Hazardous Decomposition Products:AIRBORNE SOLIDS AND LIQUID
PARTICULATES AND GASES WILL EVOLVE WHEN MATERIAL UNDERGOES
PYROLYSIS OR COMBUSTION. CARBON MONOXIDE AND UNIDENTIFIED ORGANIC
COMPOUNDS MAY BE FORMED UPON COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:THE COMPONENTS OF THIS PRODUCT ARE LISTED ON THE EPA/TSCA
INVENTORY OF CHEMICAL SUBSTANCES. EPA- CLEAN WATER ACT (CWA): THIS
PRODUCT IS CLASSIFIED AS AN OIL UNDER SECTION 311 OF THE CLEAN
WATER ACT. SPILLS ENTERING SURFACE WATERS OR ANY WATERCOURSES OR
SEWERS ENTERING/LEAVING TO SURFACE WATERS THAT CAUSE A SHEEN MUST
BE REPORTED TO THE NATIONAL RESPONSE CENTER, 800-424-8802. UNDER
SARA TITLE III , SECTION 313, THIS PRODUCT CONTAINS ANTIMONY
COMPOUNDS.

Transport Information:DEPARTMENT OF TRANSPORTATION CLASSIFICATION: NOT
HAZARDOUS BY D.O.T. REGULATIONS.

SARA Title III Information:UNDER SARA TITLE III, SECTION 313, THIS
PRODUCT CONTAINS ANTIMONY COMPOUNDS.